Đang tải... (xem toàn văn)
Shop manual máy đào HuynDai R170W-9 (Phần 2) Phần hệ thống điện
4-24GROUP 3 ELECTRICAL COMPONENT SPECIFICATIONGROUP 3 ELECTRICAL COMPONENT SPECIFICATION1CSTACCBRHB24HI0,I0356543216CS-2CBASUPPLYSIGRETURNCD-7 CD-24 CD-31CD-35 CD-38 CD-42CD-44 CD-69 CD-70CD-74CD-3 CD-4 CD-5CD-32CD-43CD-73CD-6ABCABCN-173CR-1CR-24Part name Symbol Specifications CheckBattery12V × 100Ah(2EA)※ Check specific gravity 1.280 over : Over charged 1.280 ~ 1.250 : Normal 1.250 below : RechargingBattery relayRated load :24V100A (continuity)1000A (30seconds)※ Check coil resistance(M4 to M4) Normal : About 50Ω ※ Check contact Normal : ∞Ω Glow plug relay 24V 200A※ Check contact Normal : 0.942Ω (For terminal 1-GND)Start keyB-BR : 24V 1AB-ACC : 24V 10AB-ST : 24V 40A※ Check contact OFF : ∞Ω(for each terminal) ON : 0Ω(for terminal 1-3 and 1-2) START : 0Ω(for terminal 1-5)Pressure sensor 8~30V※ Check contact Normal : 0.1ΩResistor 4W※ Check resistance A-B : 120Ω 4-25Part name Symbol Specifications CheckGlow plug 24V 200A※ Check resistance 0.25~0.12ΩTemperature sensor(hydraulic)-※ Check resistance 50˚C : 804Ω 80˚C : 310Ω 100˚C : 180Ω Air cleanerpressure switch(N.O TYPE)※ Check contact High level : ∞Ω Low level : 0ΩFuel sender -※ Check resistance Full : 50Ω 6/12 : 350Ω 11/12 : 100Ω 5/12 : 400Ω 10/12 : 150Ω 4/12 : 450Ω 9/12 : 200Ω 3/12 : 500Ω 8/12 : 250Ω 2/12 : 550Ω 7/12 : 300Ω 1/12 : 600Ω Empty warning : 700Ω Relay(air con blower,head lamp,cabin lamp,fuel heater)24V 20A※ Check resistance Normal : About 200Ω (for terminal 1-3) 0 Ω (for terminal 2-4)Relay 24V 16A※ Check resistance Normal : About 160 Ω (for terminal 1-2) 0Ω(for terminal 3-4) ∞Ω(for terminal 3-5) 12CD-8C21PaCD-2CD-1 CD-10CN-80CR-4 CR-13 CR-14CR-46 CR-78 CR-81CR-82 CR-83 CR-84123431241234521534CR-5 CR-12 CR-15CR-36 CR-45 CR-62CR-63 CR-66 4-26Part name Symbol Specifications CheckReplay 24V 200A※ Check resistance 0.25~0.12ΩSolenoid valve -※ Check resistance 50˚C : 804Ω 80˚C : 310Ω 100˚C : 180Ω Air cleanerpressure switch(N.O TYPE)※ Check contact High level : ∞Ω Low level : 0ΩFuel sender -※ Check resistance Full : 50Ω 6/12 : 350Ω 11/12 : 100Ω 5/12 : 400Ω 10/12 : 150Ω 4/12 : 450Ω 9/12 : 200Ω 3/12 : 500Ω 8/12 : 250Ω 2/12 : 550Ω 7/12 : 300Ω 1/12 : 600Ω Empty warning : 700Ω Relay(air con blower)24V 20A※ Check resistance Normal : About 200Ω (for terminal 1-3) 0 Ω (for terminal 2-4)Relay 24V 16A※ Check resistance Normal : About 160 Ω (for terminal 1-2) 0Ω(for terminal 3-4) ∞Ω(for terminal 3-5) 12CN-75 CN-133 CN-238CN-239 CN-240 CN-241CN-242 CN-24687a3087858687a85878630CR-2 CR-7 CR-9CR-29 CR-30CR-47 CR-79CR-3512CN-68 CN-69 CN-70CN-122 CN-123 CN-128CN-140 CN-149 CN-153CN-88CN-135CN-154CN-181 CN-206 CN-214 CN-216CN-220 CN-236 CN-23737121134567891011124810921122CS-23 CS-52 CS-67CS-82 CS-83 CS-99CS-79CS-10012CN-23(LH)CN-24(RH)S+-ABCCN-142 4-27Part name Symbol Specifications Check Room lamp 24V 10W※ Check disconnection Normal : 1.0Ω ON : 0Ω(For terminal 1-2) ∞Ω(For terminal 1-3) OFF : ∞Ω(For terminal 1-2) 0Ω(For terminal 1-3)Work lamp,Cab lamp,Number platelamp24V 65W(H3 Type)※ Check disconnection Normal : 1.2ΩBeacon lamp21V 70W(H1 Type)※Check disconnection Normal : A fewΩFuel filler pump24V 10A35ℓ /min※Check resistance Normal : 1.0ΩService meter 16 ~ 32V※Check operation Supply power(24V) to terminal No.2 and connect terminal No.1 and groundHornDC22 ~ 28V2A※Check operation Supply power(24V) to each terminal and connect ground.12CL-5 CL-6 CL-8CL-9 CL-21321CL-112MCN-61MCL-7-h321CN-48CL-7CN-20 CN-2512 4-28CS-20 CS-5312345678910111213141516ACCILL-GNDSPK FRT RH-SPK FRT LH-TEL MUTEANT 12VBACK UP+ILL+NCSPK FRT RH+REMOCON+REMOCON GNDSPK FRT LH+NCGNDCN-27P12CN-29CN-29Part name Symbol Specifications CheckSafety switch 24V 15A(N.C TYPE)※ Check disconnection Normal : 1.0Ω ON : 0Ω(for terminal 1-2) ∞Ω(for terminal 1-3) OFF : ∞Ω(for terminal 1-2) 0Ω(for terminal 1-3)Wiper cut switch24V(N.O TYPE)※ Check contact Normal : 0Ω(one pin to ground)Receiver dryer24V 2.5A※Check contact Normal : ∞ΩRadio &CD/MP3 player24V 2A※Check voltage 20~25V (for terminal 1-3, 3-8)Washer pump 24V 3.8A※Check contact Normal : 10.7Ω(for terminal 1-2)Wiper motor 24V 2A※Check disconnection Normal : 7Ω(for terminal 2-6)12MCN-2246532123456MCN-21231123CS-4CS-4 CS-20CS-53 4-2924VGND12V12324V12VCN-138CL-2CL-2B+MMCN-45CN-811CN-28Part name Symbol Specifications CheckDC/DCConverter 12V 3A24V (1-2)12V (1-3)Cigar lighter 24V 5A 1.4W※Check coil resistance Normal : About 1MΩ ※Check contact Normal : ∞Ω Operating time : 5~15secAlternatorCummins24V 55A※Check contact Normal : 0Ω (for terminal B+-I) Normal : 24~27.5VStarterDenso24V 4.5kW※Check contact Normal : 0.1ΩTravel alarm24V 0.5A※Check contact Normal : 5.2ΩAirconcompressor24V 79W※Check contact Normal : 13.4ΩB+PLG~3U123FI4NCCN-74 4-30Part name Symbol Specifications CheckStart relay24V 300A※Check contact Normal : 0.94Ω(for terminal 1-2)Blower motor 24V 9.5A※Check resistance Normal : 2.5Ω(for terminal 1-2)Duct sensor(switch)1˚C OFF4˚C ON※Check resistance Normal : 0Ω(for terminal 1-2), the atmosphere temp : Over 4˚CDoor switch 24V 2W※Check resistance Normal : About 5MΩSwitch(power max, one touch decal, horn, breaker)24V 6A※Check resistance Normal : ∞ΩFusible link 60A※Check disconnection normal : 0Ω (connect ring terminal and check resist between terminal 1 and 2)M1212CS-1CR-23CS-1 12CS-5 CS-19CS-26 CS-26A CS-2912CN-95CN-60 4-31Part name Symbol Specifications CheckMaster switch6 - 36V※Check disconnection Normal : 0.1ΩRear combination lamp-LH,RH24V 21W×324V 10W※Normal : 4.8Ω (For terminal 1-4) Normal : 2.1Ω (For terminal 2-4, 4-5, 4-6)Front combination lamp-LH, RH24V 21W24V 10W※Normal : 4.8Ω (For terminal 1-2) Normal : 2.1Ω (For terminal 2-3)Head lamp-LH, RH24V 75/70W※Normal : 1.0Ω (For terminal 1-3, 2-3) Normal : 1.5Ω (For terminal 1-2)21CS-741234TATUNCEH5BU6STCL-15 CL-16123CETCL-24 CL-25123LoHiECL-3 CL-4 . CR -3 0 CR-47 CR-79CR -3 5 12CN-68 CN-69 CN-70CN-122 CN-1 23 CN-128CN-140 CN-149 CN-153CN-88CN- 135 CN-154CN-181 CN-206 CN-214 CN-216CN-220 CN- 236 CN- 237 37121 134 567891011124810921122CS- 23. SPECIFICATION1CSTACCBRHB24HI0,I 035 65 432 16CS-2CBASUPPLYSIGRETURNCD-7 CD-24 CD -3 1 CD -3 5 CD -3 8 CD-42CD-44 CD-69 CD-70CD-74CD -3 CD-4 CD-5CD -3 2 CD-43CD-73CD-6ABCABCN-173CR-1CR-24Part name Symbol Specifications