Đang tải... (xem toàn văn)
Bioethanol obtained by fermenting cellulosic fraction of biomass holds promise for blending in petroleum. Cellulose hydrolysis yields glucose while hemicellulose hydrolysis predominantly yields xylose.
Sharma et al Chemistry Central Journal (2018) 12:8 https://doi.org/10.1186/s13065-018-0375-8 RESEARCH ARTICLE Open Access Notable mixed substrate fermentation by native Kodamaea ohmeri strains isolated from Lagenaria siceraria flowers and ethanol production on paddy straw hydrolysates Shalley Sharma1, Anju Arora1*, Pankhuri Sharma1, Surender Singh1, Lata Nain1 and Debarati Paul2 Abstract Background: Bioethanol obtained by fermenting cellulosic fraction of biomass holds promise for blending in petroleum Cellulose hydrolysis yields glucose while hemicellulose hydrolysis predominantly yields xylose Economic feasibility of bioethanol depends on complete utilization of biomass carbohydrates and an efficient co-fermenting organism is a prerequisite While hexose fermentation capability of Saccharomyces cerevisiae is a boon, however, its inability to ferment pentose is a setback Results: Two xylose fermenting Kodamaea ohmeri strains were isolated from Lagenaria siceraria flowers through enrichment on xylose They showed 61% glucose fermentation efficiency in fortified medium Medium engineering with 0.1% yeast extract and peptone, stimulated co-fermentation potential of both strains yielding maximum ethanol 0.25 g g−1 on mixed sugars with ~ 50% fermentation efficiency Strains were tolerant to inhibitors like 5-hydroxymethyl furfural, furfural and acetic acid Both K ohmeri strains grew well on biologically pretreated rice straw hydrolysates and produced ethanol Conclusions: This is the first report of native Kodamaea sp exhibiting notable mixed substrate utilization and ethanol fermentation K ohmeri strains showed relevant traits like utilizing and co-fermenting mixed sugars, exhibiting excellent growth, inhibitor tolerance, and ethanol production on rice straw hydrolysates Keywords: Yeast, Kodamaea ohmeri, Fermentation efficiency, Mixed sugar fermentation, Inhibitors, Rice straw hydrolysates Background Recent environmental disturbances, fluctuating prices, and uncertainties associated with the use of conventional fuels, have led to paradigm shift to displace conventional fuels with sustainable, renewable, and environmentally friendly/clean energy sources, among which biomassderived energy appears to be the most promising option [1] Of various alternative energy sources, bioenergy derived from lignocellulosic biomass has attracted significant attention as one of the routes to address energy *Correspondence: anjudev@yahoo.com Division of Microbiology, ICAR-Indian Agricultural Research Institute, New Delhi 110012, India Full list of author information is available at the end of the article crisis, especially bioethanol in transport sector [2] Second generation bioethanol, produced by fermenting sugar slurries obtained from enzymatic hydrolysis of cellulose present in lignocellulosic biomass, has the potential of being a major contributor to meet the global energy demand, as biomass is the most abundant, sustainable, and renewable resource on earth However, unfavorable economics is the foremost impediment in successful deployment of this process on industrial scale An efficient pretreatment with lower inhibitor generation followed by enzymatic hydrolysis for maximum sugar recovery, and complete utilization and fermentation of all the sugars present in hydrolysates will aid in making the process cost effective [3] In addition to cellulose, © The Author(s) 2018 This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/ publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated Sharma et al Chemistry Central Journal (2018) 12:8 biomass also has hemicellulose, which is the second major polysaccharide, consisting of hexoses and pentoses, with xylose as the major pentose sugar Thus, complete conversion of lignocellulosic biomass entails a co-fermenting yeast, capable of fermenting both glucose and xylose yielding high ethanol titers Development of strains for use in industrial-scale facilities is continuously being carried out in parallel with the process optimization Commercial strains of S cerevisiae, the most widely used organisms for ethanol production are exclusively involved in glucose fermentation, thus completely utilizing cellulosic fraction while xylose is left unfermented To overcome this drawback of S cerevisiae, recombinant strains capable of utilizing xylose have been developed since 1980s but ethanol yield was found to be low [4] Since then, several genetic engineering approaches have been adopted for developing a recombinant strain capable of mixed substrate fermentation but with limited success [5] This is due to the constraints associated with co-fermentation, like aerobic process of xylose fermentation, co-factor (NADH) imbalance [6] and glucose repression [7, 8] In addition, inhibitors present in biomass hydrolysates [9] and medium constituents [10] have been observed to affect yeast physiology and fermentation efficiency [11, 12] All these issues need to be addressed earnestly On the other hand, native pentose fermenting yeasts are well known [4, 13] First report of ethanol production from xylose by yeast came in 1958 when Karczewska [14] observed ethanol production from Candida tropicalis Pichia and Scheffersomyces are the most interesting pentose fermenting yeasts but their co-fermenting abilities on mixed substrates are yet to be established to the extent suitable for commercial application [15] Numerous native yeasts are known for xylose assimilation but very few are reported for efficient fermentation of xylose to ethanol Such yeast include Pichia, Candida, Pachysolen, Clavispora, Debaromyces, Kluyveromyces, Cryptococcus, Rhodotorula etc Researchers have demonstrated low to high ethanol production from xylose in rich medium, by different yeasts isolated from natural habitats like tree bark, decaying wood samples and insect gut [16–18] Mixed substrate utilization and co-fermentation is still a challenge Thus, rational bio prospecting for native pentose assimilating and fermenting yeasts is the contemporary approach and increasing efforts have recently been put into evaluating natural xylose fermenting potential of yeasts [19, 20] A yeast genus Kodamaea, earlier placed under Pichia genus has been reported for pentose utilization including xylose and arabinose but fermentation of pentoses to ethanol has not been reported A novel sp of Kodamaea, K kakuduensis, isolated from Australian Hibiscus flower, Page of 11 was reported to be a good glucose fermenter with weak xylose assimilation properties [21] Kodamaea ohmeri has been explored for its food fermentation properties especially for pickling and cocoa beans but ethanol production has not been reported yet [22] Zhu et al [23] described d-arabitol as the main product from glucose by K ohmeri This study illustrates mixed sugar utilization, ethanol fermentation potential, and inhibitor tolerance of two native K ohmeri strains isolated from the flowers of L siceraria plant for their possible exploitation in bioethanol production Experimental Isolation of yeast strains Lagenaria siceraria flowers were collected, washed with distilled water and crushed in pestle mortar with 0.8% saline under aseptic conditions. 1 mL of this suspension was inoculated into 50 mL MXYP broth (0.5% malt extract, 1% xylose, 0.5% yeast extract and 0.3% peptone, pH 5) in 100 mL flasks with 0.25% sodium propionate, for enrichment of xylose utilizing yeasts After 48 h incubation at 30 °C, culture samples were plated on MXYP agar with chloramphenicol (50 µg mL−1) antibiotic Plates were incubated for 24 h at 30 °C and colonies were selected based on their morphology Selected colonies were purified and grown on same medium and glycerol stocks were prepared Identification and characterization of selected yeast strains Two potent xylose assimilating strains were selected, strain and strain Both the strains were characterized on morphological, biochemical as well as on molecular level Phenotypic characterization was done on the basis of their colony and cell morphology using phase contrast microscopy and scanning electron microscopy Molecular characterization included sequencing of the ITS region of the yeast strains Studying cell morphology using phase contrast microscopy and scanning electron microscopy To study morphology, overnight grown cultures were observed under phase contrast microscope (Olympus America Inc.) at magnification 10× and 40× Cell morphology was also studied using scanning electron microscope (Zeiss EVOMA10) Overnight incubated cultures on xylose (1 mL) were centrifuged at 8000g for 10 min, 2.5% glutaraldehyde fixative was added to the pellet and kept for 2–4 h to arrest growth Cultures were then washed with 0.1 M phosphate buffer thrice at an interval of 15 Samples were dehydrated with a graded series of acetone (30, 50, 70, 80, 90, 95 and 100%), fixed on cover slips placed over stuff grids A drop of hexamethyl disilazone was added over the cover slips and then Sharma et al Chemistry Central Journal (2018) 12:8 Page of 11 allowed to dry in a fume hood Cells were observed with scanning electron microscope at an acceleration voltage of 20 kV and images recorded Table 1 Reaction cocktail for xylose reductase activity Molecular identification through ITS sequencing Further confirmation was done by PCR amplification of ITS region PCR procedures involved denaturation at 95 °C for 5 min, followed by 35 cycles of 94 °C for 5 min, 55 °C for 30 s and extension at 72 °C for 45 s, with final extension for 10 at 72 °C Amplified products were run over 1% agarose gel to confirm their molecular size ITS sequencing of the amplified products was completed by Xcelris, India and further analyzed using Basic Local Alignment Search Tool (BLAST) [24] Partial sequencing of the strains was done using ITS and ITS degenerate primers i.e., ITS1-forward primer (5′-TCCGTAGGTGAACCTGCGG-3′) and ITS4-reverse primer (5′-TCCTCCGCTTATTGATATGC-3′) [25] Biochemical characterization Ability of Kodamaea ohmeri strains to assimilate different sugars was tested using biochemical strips (Hi Media) for yeast Overnight cultures were inoculated on the strips (100 µL each) and incubated at 28 °C Results were observed for 72 h Determining enzyme activities K ohmeri strains were grown for 48 h on 2% xylose, and mixed sugars (2% xylose + 2% glucose) in minimal medium with shaking at 150 rpm at 30 °C After 48 h, cultures were centrifuged at 8000 rpm for 10 and supernatant was discarded Pellet was processed for xylose reductase (XR) and xylitol dehydrogenase (XDH) activities were measured and expressed as specific activities Protein concentration in crude extracts was measured using BSA as standard Solution Volume (µL) Control Experimental DI water 200 100 Potassium phosphate 600 600 2-Mercaptoethanol 100 100 NADPH 50 50 Xylose 100 Table 2 Reaction cocktail for xylitol dehydrogenase activity Solution Volume (µL) Control Experimental DI water 300 200 500 mM tris–HCl 400 400 2-Mercaptoethanol 100 100 NAD+ 100 100 Xylitol 100 of the rate of change of absorbance per at 340 nm was measured and considered as the XDH activity for K ohmeri strain and strain Fermentation abilities of K ohmeri strains Pellet obtained was washed twice with phosphate buffer (250 mM, pH 7.0), sonicated, and the lysate was then used as the crude enzyme extract Two cocktails were prepared as shown in Table 1 Crude enzyme was added to the experimental vial (50 µL) and readings were taken at 340 nm for 3 and the rate of change of OD was used to determine the activity of the enzyme Both strains were grown in minimal medium (1.36 mg L−1 KH2PO4, 0.2 g L−1 MgSO4·7H2O, 2.0 g L−1 NaCl, 1.0 g L−1 (NH4)2SO4, 10 mg L−1 FeSO4, pH 5) with 5% xylose/10% glucose or both as carbon source for 72 h at 30 °C to check their ability to grow and ferment xylose Effect of salts like NaCl and FeSO4 was studied Medium (50 mL) in 100 mL Erlenmeyer flasks was inoculated (10% inoculum) and incubated for 72 h at 30 °C Inoculum was prepared in MXYP broth (pH 7.0) by incubating it at 30 °C for 48 h and shaking (150 rpm) Aliquots were aseptically withdrawn at regular intervals and the absorbance read at 660 nm (Specord 200) to measure growth These aliquots were then centrifuged at 10,000 rpm for 10 and supernatants were used for estimation of sugar consumption and ethanol production by HPLC as described later Xylitol dehydrogenase Fermentation of mixed sugars Pellet obtained was washed twice with Tris–Cl buffer (500 mM, pH 8.6), sonicated and the lysate was then used as the crude enzyme extract For this assay, two cocktails were prepared as shown in Table 2, in two separate cuvettes and kept on ice Crude enzyme (50 µL) was added to the experimental vial and measurements Cultures were grown on mixed sugars (5% glucose + 5% xylose) as carbon source in minimal medium (10 g L−1 KH2PO4, 5 g L−1 (NH4)2SO4, 5 g L−1 MgSO4·7H2O, 1 g L−1 yeast extract, pH 5) Composition of minimal medium in this case differed from the above experiment as effect of salts and yeast extract was being monitored Xylose reductase Sharma et al Chemistry Central Journal (2018) 12:8 Page of 11 Fermentation was carried out in two phases Incubation at 30 °C under shaking for 48 h for biomass production was switched to static conditions for ethanol production Samples were analyzed for growth, sugar consumption and ethanol production Fermentation efficiency was calculated as [26] %Fermentation Efficiency = Actual Ethanol Yield in grams / Theoretical Ethanol Yield in grams × 100 (1) Theoretical Ethanol yield = sugar consumed in grams × 0.511) (2) Stimulation of fermentation ability upon medium supplementation Effect of medium supplementation with yeast extract and peptone on ethanol production was studied Treatments with combinations of yeast extract (0.1–1%) and peptone (0.1 and 1%) with pure or mixed sugars (10% glucose or 10% glucose + 5% xylose) were applied Incubation was carried out as described earlier and samples were analyzed for growth and fermentation Analytical methods Ethanol levels were estimated using chromatographic techniques, such as HPLC and GC High performance liquid chromatography Cultures were harvested at regular intervals, centrifuged at 8000 rpm for 10 min, filtered using 0.22 µ syringe filters and subjected to analysis by HPLC Samples were run on Aminex HPX-87H column (Bio-Rad, Hercules, CA, USA) at 65 °C using 5 mM H 2SO4 as mobile phase at 0.5 mL min−1 and measured with a Shodex RI-101 refraction index detector (Shoko Scientific Co Ltd., Yokohama, Japan) Ethanol concentration and sugar consumption were determined Inhibitor tolerance of K ohmeri strains For exploitation of K ohmeri strains for fermentation of biomass hydrolysates, it is important to check their capability to grow in presence of HMF, furfural, formic acid and acetic acid, the predominant by-products of biomass pretreatment which are present in hydrolysates and reported to inhibit growth Cultures were grown in presence of HMF (0.5– 5.0 g L−1) and furfural (0.25–0.65 g L−1) in minimal medium with 5% glucose + 2.5% xylose and 0.1% yeast extract for 96 h Growth was checked every 24 h by reading absorbance at 660 nm Appropriate controls were maintained and growth was compared Similar experiment was carried out using acetic acid (5–15 g L−1) and formic acid (3–11 g L−1) under similar conditions All the experiments were carried out in triplicates Growth and fermentation on biologically pretreated paddy straw hydrolysates Rice straw of the aromatic rice (Pusa 2511) was pretreated under solid state fermentation using Trametes hirsute, for 7 days and cellulose content was analysed in pretreated solids [27] Enzymatic hydrolysis of biologically pretreated solids was carried out using accellerase®1500 (Genencor) loading corresponding to 0.5 mL (~ 15 FPU) per g glucan [28] Total sugars in hydrolysates were estimated using DNS [29] Both strains were grown in hydrolysates [30] and culture samples were periodically withdrawn Samples were processed Growth and sugar consumption were observed Ethanol production was detected by HPLC Defined medium with 1.3% glucose served as control Statistical analyses of the results was done using SPSS (Version 21.0 Armonk, NY: IBM Corp) Results and discussion Growth and characterization Lagenaria siceraria flowers are rich in pentose and hexose sugars and thus used as a source for isolating pentose assimilating K ohmeri strains [31] K ohmeri strains were isolated and purified from L siceraria flowers by enrichment on MXYP medium and maintained as glycerol stocks Both the strains grew well on minimal medium with xylose as sole carbon source (Additional file 1: Figure S1) They showed distinct opaque, butyroid, creamy, circular colony morphology with regular margins and raised elevation Under phase contrast microscope, cells appeared ovoid and occurred singly (Additional file 1: Figure S2) Scanning electron microscopy images showed shrunk cells with irregular margins indicating stress Budding cells were also observed under scanning microscopy (Fig. 1) Biochemical characterization showed that both strains could assimilate maltose, sucrose, galactose, cellobiose, raffinose, trehalose, glucose and xylose while inositol, dulcitol, lactose, melibiose were not assimilated and urease test was also negative (Additional file 1: Table S1) Both strains were identified to be K ohmeri upon partial sequencing Strain (GenBank Accession No KT598022) showed 100% similarity with K ohmeri while strain (GenBank Accession No KT598023) displayed 97% similarity Phylogenetic tree constructed using Maximum-Likelihood [32] also showed their relationship with K ohmeri (Fig. 2) Kodamaea genus was earlier placed under Pichia genus but was separated later due to considerable genetic distances as measured by partial sequences of 18S and 26S ribosomal RNA and only seven Sharma et al Chemistry Central Journal (2018) 12:8 Page of 11 Fig. 1 Scanning electron micrographs of strain and strain Cells of strain (a) and strain (b) appear stressed due to growth on xylose under micro-aerophilic conditions Budding cells are clearly visible in the electron micrographs species were placed under the genus Kodamaea including K anthophila, K kakaduensis, K ohmeri, K laetipori, K nitidulidarum, K transpacifica, K meredithae have been described [33–35] production Specific activities (U mg−1 protein) of the strains were found to be 0.024, 0.2 (XR) for strain and respectively, while 0.011 and 0.015 (XDH) for strain and strain respectively Attributes pertaining xylose metabolism Fermentation and co‑fermentation capabilities and effect of supplementation Xylose reductase and xylitol dehydrogenase enzyme activities pertaining to xylose metabolism [36, 37] were exhibited by both the strains but levels were low The activities suggested the presence of xylose metabolizing pathway in these strains but levels were too low and their ratio predicted the flow of the pathway towards ethanol As evident from absorbance at 660 nm, both the strains grew well on minimal medium with xylose as sole carbon source and also on mixture of xylose and glucose and fermented them to ethanol (data not shown) On minimal medium containing salts, ethanol was produced by both K ohmeri strain AUMC (JQ425350) Saccharomycetales sp LM378 (EF060692) K ohmeri (FM178297) Pichia guilliermondii (FM178323) K ohmeri strain 12H4074 (KU052083) Hanseniaspora uvarum strain WZ1 (DQ666349) K ohmeri strain (KT598022) Saccharomycetales sp LM342 (EF060661) K ohmeri strain CBS5367 (GU246263) K ohmeri CBS 5376 (NR_121464) K ohmeri isolate A-10 (KC556812) Pichia ohmeri strain ST5-3 (AY168786) K ohmeri strain WM 10.2 (KP068945) K ohmeri isolate (KF385982) K ohmeri strain wwl-1 (EF190229) K ohmeri strain PWQ2177 (KP132357) Candida digboinses isolate SUMS0395 (FJ011540) Kodamaea sp NRRL Y27634 (AY911385) K ohmeri strain (KT598023) Rhodotorula sp W500 (DQ781315) 0.1 Fig. 2 Phylogenetic tree of K ohmeri strain and strain Sharma et al Chemistry Central Journal (2018) 12:8 Page of 11 strains with fermentation efficiency of ~ 25 and ~ 5% on glucose and xylose respectively (Fig. 3; Additional file 1: Table S2) Ethanol was the major product of glucose and xylose fermentation though trace amounts of xylitol and acetic acid were also detected during mixed sugar fermentation Higher ethanol yield of 0.31 g g−1 from glucose with fermentation efficiency of 61% was obtained when minimal medium w as supplemented with 1% yeast extract (YE) and 1% peptone (Table 3) without salts In a study, d-arabitol production was observed as main product from glucose as the carbon source on rich medium (with 1% YE and 1% peptone) by K ohmeri, and only trace amounts ethanol were observed Production levels of polyols as fermentation products, largely depend on factors like proper ratio of nitrogen, carbon sources in the medium, original habitat of the fermenting organism and growth conditions [23] Presence of salts in growth medium influence physiology, hamper growth and distress fermentation efficiency in yeasts while medium (a) Xylose Fermentation 100 (b) Glucose Fermentation 100 50 50 with organic supplements augment ethanol fermentation efficiency Supplementation with 0.1% YE and 0.1% peptone enhanced fermentation efficiency (to ~ 50%) (Table 4) Further enhancing level of supplementation in medium with higher concentrations of YE/peptone did not increase fermentation efficiency significantly Studies have suggested significant role of cultivation media components to provide favorable conditions for growth and product formation [10] Xylose consumption was also enhanced to ~ 40% during co-fermentation and highest ethanol yield was 0.25 g g−1 sugar consumed when Kodamaea were grown on 10% total mixed sugars (5% glucose + 5% xylose) Amongst most of the pentose utilizing yeasts only a few have been reported to produce ethanol as major product from pentose fermentation [38] A mixed sugar fermenting yeast, Candida lignohabitans possessing remarkable capability to ferment both pentoses and Strain Xylose consumed (%) Strain Fermentation efficiency (%) Strain Strain Glucose consumed (%) Fermentation efficiency (%) Fig. 3 Xylose (a) and glucose (b) fermentation efficiency on minimal media with salts Salts hamper the fermentation process as is visible from the lower fermentation efficiencies Table 3 Glucose utilization and ethanol yield of strain and strain Treatment Glucose (g L−1) Ethanol yield (g g−1) Strain Time (h) 96 108 120 96 108 120 90.40 ± 16.6 97.95 ± 1.8 88.90 ± 17.2 0.16 ± 0.04 0.28 ± 0.05 0.20 ± 0.09 0.5% yeast extract 99.97 ± 0.06 100 100 0.16 ± 0.09 0.25 ± 0.06 0.28 ± 0.12 1% yeast extract + 1% peptone 97.74 ± 3.71 99.91 ± 0.16 100 0.13 ± 0.02 0.12 ± 0.02 0.12 ± 0.02 0.1% yeast extract + 0.1% peptone 100 99.9 ± 0.17 100 0.12 0.14 ± 0.01 0.12 ± 0.02 0.5% yeast extract 99.18 ± 1.42 100 100 0.22 ± 0.05 0.24 ± 0.12 0.13 1% yeast extract + 1% peptone 100 99.83 ± 0.21 100 ± 0.01 0.24 ± 0.14 0.31 ± 0.10 0.20 ± 0.10 SEm (±) 1.61 0.23 1.71 0.02 0.02 0.02 CD @5% 4.46 0.64 4.73 0.05 0.06 0.05 0.1% yeast extract + 0.1% peptone Strain Ethanol yield (g g−1) = {concentration of ethanol produced (g L−1)/concentration of sugar consumed (g L−1)} SEm standard error of mean, CD critical difference 12.2 ± 0.67 1.24 3.41 1% (YE + P) SEm (±) CD @5% YE + P yeast extract + peptone 11.7 ± 1.7 15.1 ± 9.13 0.1% (YE + P) 0.5% (YE) Strain 18.8 ± 0.57 20.3 ± 2.2 17.7 ± 2.8 0.5% (YE) 1% (YE + P) 2.92 1.06 66.6 ± 2.4 18 ± 6.15 13 ± 4.3 15 ± 7.4 20.4 ± 3.2 96 20.47 ± 1.9 Time (h) 108 Xylose consumed (g L−1) 0.1% (YE + P) Strain Treatment 120 1.38 0.50 14.9 ± 0.12 14.2 ± 3.8 14 ± 0.45 13.3 ± 0.02 14.3 ± 1.9 16.2 ± 3.05 0.00 0.00 50 50 49.4 50 50 37.1 96 0.06 0.02 50 50 49.3 ± 0.19 50 50 37.9 108 0.00 0.00 50 50 50 50 50 37.9 120 Glucose consumed (g L−1) 0.03 0.01 0.25 ± .007 0.2 ± 0.01 0.25 ± 0.02 0.21 ± 0.03 0.16 ± 0.02 0.22 96 0.03 0.01 0.18 ± 0.03 0.19 ± 0.06 0.19 ± 0.05 0.19 ± 0.07 0.17 ± 0.01 0.21 ± 0.017 108 Ethanol yield (g g−1) Table 4 Effect of supplementation on sugar utilization and ethanol yield of K ohmeri strains 120 0.01 0.01 0.18 ± 0.001 0.2 ± 0.03 0.2 ± 0.001 0.2 ± 0.001 0.18 ± 0.01 0.22 ± 0.033 6.80 2.46 49.5 ± 1.5 38.7 ± 18.1 48.6 ± 3.13 41.3 ± 5.4 32 ± 4.5 44 ± 3.3 96 5.74 2.08 36 ± 5.3 38 ± 12.1 38 ± 8.8 37.1 ± 14.6 32.5 ± 1.5 40.8 ± 6.5 108 Fermentation efficiency (%) 120 2.85 1.03 35.1 ± 0.28 39.6 ± 6.2 39.7 ± 0.25 39.7 ± 0.18 34.9 ± 2.4 43.6 ± 5.9 Sharma et al Chemistry Central Journal (2018) 12:8 Page of 11 Sharma et al Chemistry Central Journal (2018) 12:8 Page of 11 Table 5 Ethanol yields of pentose fermenting strains Fermentable sugar Ethanol yields (g g−1) Reference C lignohabitans Glucose + xylose 0.2 [7] K kakuduensis Glucose Traces [21] K ohmeri Glucose Traces (by product) [23] K ohmeri strain Xylose + glucose 0.28 This study K ohmeri strain Xylose + glucose 0.31 This study 1.5 0.5 0 2.5 0.5 24 48 Time (h) 72 96 Strain HMF-0.5mg/mL 1.0 mg/mL 2.0 mg/mL 3.0 mg/mL 5.0 mg/mL 72 96 Strain (Control) mg/ml 10 mg/ml 15 mg/ml (b) Effect of Acetic Acid on Strain 2.5 1.5 0.5 0 (b) Effect of HMF on Strain 2.5 48 Time (h) 1.5 24 (a) Effect of HMF on Strain Absorbance (660 nm) Absorbance (660 nm) -0.5 Absorbance (660 nm) (a) Effect of Acetic acid on Strain 2.5 Absorbance (660 nm) Strain 24 48 Time (h) 72 Strain (Control) mg/ml 10 mg/ml 15 mg/ml 96 Fig. 5 Effect of acetic acid over K ohmeri strain 5 (a) and strain 6 (b) Strain exhibits a sudden rise in efficiency after 48 h at a concentration of 5 g L−1 1.5 0.5 0 Strain 2.0 mg/mL 24 48 Time (h) HMF-0.5mg/mL 3.0 mg/mL 72 96 1.0 mg/mL 5.0 mg/mL Fig. 4 Effect of hydroxy methyl furfural on strain (a) and strain (b) Growth pattern is similar to the control in case of strain and 0.5– 3.0 g L−1 concentration of the HMF is not inhibitory for the growth hexoses, exhibited highest ethanol yield of 0.2 g g−1 on rich medium containing 1% yeast extract and 2% soya peptone with 2–5% carbon sources, while no ethanol was detected on minimal medium without supplementation This might be due to the lower biomass accumulation on minimal medium [7] In this study, K ohmeri strain exhibited high ethanol yield during mixed substrate fermentation with minimal supplementation Insignificant increase in fermentation efficiency upon medium with higher supplementation suggested to avoid excessive nutrient supplementation as it favors biomass production [23] Table shows ethanol yields of related yeast strains Zheng et al [3] observed stimulating effect of supplementation on acetone-butanol fermentation using Clostridium saccharoperbutylacetonicum and stated that lower supplementation is cost effective and reduces overall production cost Inhibitor tolerance Lignocellulosic biomass is pretreated to facilitate higher conversion of biomass polysaccharides to fermentable sugars such as glucose, xylose, arabinose etc This process generates by-products which inhibit growth of microbes and obstruct fermentation process In general, these inhibitors are classified into four groups including lignin degradation by-products (phenolics), sugar degradation by-products (HMF and furfural), and products derived from the structure of the biomass and heavy metal ions (chromium and nickel) [39] Effect of most commonly found inhibitors like HMF, furfural, acetic acid and formic acid was determined on growth of K ohmeri strains Concentration ranges were selected based on yields commonly reported in literature and mostly encountered Sharma et al Chemistry Central Journal (2018) 12:8 Page of 11 (a) Strain Sugar consumed (%) 100 98 96 1.5 94 92 0.5 90 88 0h 24 h 72 h 96 h Strain (Control) Strain (Hydrolysate) Growth (Control) Growth (Hydrolysate) (b) Strain 102.0 Sugar consumption (%) 48 h 2.5 100.0 2.0 98.0 96.0 1.5 94.0 1.0 92.0 0.5 90.0 88.0 0h 24 h 48 h 72 h Absorbance (660 nm) 2.5 96 h Absorbance (660 nm) 102 0.0 Strain (Control) Strain (Hydrolysate) Growth (Control) Growth (Hydrolysate) Fig. 6 Sugar consumption (%) and growth of K ohmeri strain (a) and strain (b) on biologically pretreated rice straw hydrolysate in biomass hydrolysates after different pretreatments [40, 41] Increasing concentrations of HMF and furfural reduced growth of both strains as compared to controls (Fig. 4) Furfural was inhibitory in initial growth stages but inhibition was gradually overcome upon prolonged growth after 96 h (Additional file 1: Figure S3) This coincided with earlier observations that furfural can reduce growth rate above a certain concentration It has been proved that furfural inhibits alcohol dehydrogenase (ADH) formation which lead to the accumulation of acetaldehyde intracellularly, causing enhanced lag phase of growth during which enzymes and co-enzymes are produced for the reduction of furfural [42] HMF also posed similar threats on growth and ethanol productivity of K ohmeri strains as growth was reduced and lesser biomass resulted in lesser ethanol production K ohmeri strains were found to be tolerant to HMF up to 3 g L−1 concentration while at 5 g L−1 concentration, growth was reduced Effect of organic acids on growth of K ohmeri strains was more pronounced With formic acid (3–11 g L−1) and acetic acid (5–15 g L−1), growth was highly affected due to pH change, as optimum pH for yeast growth is 5–6 Formic and acetic acids at concentration used in these experiments reduced pH to leading to reduction in biomass production In case of acetic acid, there was a sudden rise in growth of both strain and strain after 48 and 72 h respectively Acetic acid at concentrations up to 6 g L−1 did not cause any reduction in growth of the strains [40] (Fig. 5) Acetic acid works by lowering intracellular pH, which is neutralized by plasma membrane’s ATPase by pumping out protons from the cell, thereby, leading to the production of additional ATPs by increasing ethanol production under anaerobic conditions due to enhanced biomass formation This might be the reason for sudden rise in growth after a certain period as observed in case of K ohmeri strains Effect of formic acid was more severe and growth of both strains was impeded Major cause of decreased growth was assumed to be lowering of pH as inhibitory effect of formic acid was nullified when pH was adjusted to optimum (data not shown) This reduction was due to drop in extracellular pH which causes diffusion of undissociated acids inside the cell leading to reduction in intracellular pH [43] ABE fermentation was repressed by the production of acetic acid produced as a byproduct when C saccharoperbutylacetonicum was grown on eucalyptus hydrolysates [3] Growth and ethanol production by K ohmeri strains from biomass hydrolysates Kodamaea ohmeri strains were evaluated for growth and ethanol production on biomass hydrolysates prepared from biologically pretreated rice straw Total sugar content in the hydrolysates was ~ 1.3% (with 2% glucan loading and 57% saccharification efficiency) Growth on hydrolysates was comparable to the control (Fig. 6) Maximum sugar consumption and ethanol production occurred within 24 h HPLC analyses of samples showed ethanol production and maximum ethanol level at 72 h by both the strains and it was ~ 2 and 1.3 g L−1 by strain and strain respectively (Table 6) Thus, these strains of K ohmeri were able to grow and produce ethanol from paddy straw hydrolysates Conclusions Screening for microbes capable of co-fermentation is necessary for efficient conversion of lignocellulosic biomass into ethanol with enhanced productivity There is a significant advancement in developing a robust microbial strain with co-fermentation potential as well as tolerance to inhibitors K ohmeri strains, studied here showed promising mixed sugar fermentation potential Sharma et al Chemistry Central Journal (2018) 12:8 Page 10 of 11 Table 6 Ethanol yields of K ohmeri strains from rice straw biomass hydrolysates Ethanol produced (g L−1) 24 h 48 h 72 h K ohmeri strain (control) 0.98 ± 0.01 0.065 ± 0.003 0.059 ± 0.0005 0.015 ± 0.0025 0.35 ± 0.01 1.92 ± 0.04 0.001 ± 0.0015 K ohmeri strain (hydrolysate) 0.3 ± 0.001 96 h K ohmeri strain (control) 1.07 ± 0.01 1.15 ± 0.05 0.71 ± 0.02 0.26 ± 0.02 K ohmeri strain (hydrolysate) 0.12 ± 0.03 0.78 ± 0.02 1.28 ± 0.01 0.04 ± 0.008 with enhanced xylose utilization Strains were also tolerant to HMF, furfural, formic acid and could grow well in presence of acetic acid on prolonged incubation The study emphasizes that this genus could provide robust native yeast strains with co-fermentation properties which can be evolved further Lignocellulosic hydrolysates often generate unexpected results due to the presence of inhibitors, as they vary widely in nature [12] These strains displayed efficient growth and ethanol production from biologically pretreated rice straw hydrolysates Additional file Additional file 1 Table S1 Sugar utilization by K ohmeri strain and strain Table S2 Ethanol production, sugar consumption and fermentation efficiency of K ohmeri strain and strain during xylose fermentation Figure S1 Growth of K ohmeri strain and strain on minimal medium with xylose as sole C source Figure S2 K ohmeri strain (A) and strain (B) as observed under phase contrast microscope Figure S3 Effect of furfural on K ohmeri strain (A) and strain (B) Authors’ contributions SS and PS carried out the experimental work AA conceptualized the study, designing experiments and helped in the finalization of manuscript Dr SS performed HPLC of all the samples Dr LN and Dr DP contributed for the saccharification and fermentation experimental work All authors read and approved the final manuscript Author details Division of Microbiology, ICAR-Indian Agricultural Research Institute, New Delhi 110012, India 2 Amity Institute of Biotechnology, Amity University, Noida, U.P., India Acknowledgements This work was supported by AMAAS (Grant No 12-124), ICAR, India Scanning electron microscopy was carried out in the Division of Entomology, ICAR-IARI, India Competing interests The authors declare that they have no competing interests Ethics approval and consent to participate Not applicable Publisher’s Note Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations Received: 22 December 2016 Accepted: 20 January 2018 References Srirangan K, Akawi L, Moo-Young M, Chou CP (2012) Towards sustainable production of clean energy carriers from biomass resources Appl Energy 100:172–186 Marcuschamer DK, Popiel PO, Simmons BA, Blanch HW (2010) Technoeconomic analysis of biofuels: a wiki-based platform for lignocellulosic biorefineries Biomass Bioenergy 34:1914–1921 Zheng J, Tashiro Y, Wang Q, Sakai K, Sonomoto K (2015) Feasibility of acetone–butanol–ethanol fermentation from eucalyptus hydrolysate without nutrients supplementation Appl Energy 140:113–119 Gong CS, Chen LF, Flickinger MC, Chiang LC, Tsao GT (1981) Production of ethanol from d-xylose by using d-xylose isomerase and yeasts Appl Environ Microbiol 41:430–436 Fernandes S, Murray P (2010) Metabolic engineering for improved microbial pentose fermentation Bioeng Bugs 1:424–428 Nilsson A, Gorwa-Grauslund MF, Hahn-Hägerdal B, Lidén G (2005) Cofactor dependence in furan reduction by Saccharomyces cerevisiae in fermentation of acid-hydrolyzed lignocellulose Appl Environ Microbiol 71:7866–7871 Bellasio M, Mattanovich D, Sauer M, Marx H (2015) Organic acids from lignocellulose: Candida lignohabitans as a new microbial cell factory J Ind Microbiol Biotechnol 42:681–691 Sharma S, Sharma S, Singh S, Arora A (2016) Improving yeast strains for pentose hexose co-fermentation: successes and hurdles In Proceedings of the first international conference on recent advances in bioenergy research, Springer, Berlin, pp 23–41 Feng Y, Qi X, Hl Jian, Sun RC, Jiang JX (2012) Effect of inhibitors on enzymatic hydrolysis and simultaneous saccharification fermentation for lactic acid production from steam explosion pretreated lespedeza stalks BioResources 7:3755–3766 10 Hahn-Hägerdal B, Karhumaa K, Larsson CU, Gorwa-Grauslund M, Görgens J, van Zyl WH (2005) Role of cultivation media in the development of yeast strains for large scale industrial use Microb Cell Fact 4:1–16 11 Casey E, Sedlak M, Ho NW, Mosier NS (2010) Effect of acetic acid and pH on the co-fermentation of glucose and xylose to ethanol by a genetically engineered strain of Saccharomyces cerevisiae FEMS Yeast Res 10:385–393 12 Cortez D, Roberto I (2006) Effect of phosphate buffer concentration on the batch xylitol production by Candida guilliermondii Lett Appl Microbiol 42:321–325 13 Jeffries TW (1981) Conversion of xylose to ethanol under aerobic conditions by Candida tropicalis Biotechnol Lett 3:213–218 14 Karczewska H (1958) Some observations on pentose utilization by Candida tropicalis Comptes-rendus des travaux du Laboratoire Carlsberg 31:251–258 15 De Bari I, De Canio P, Cuna D, Liuzzi F, Capece A, Romano P (2013) Bioethanol production from mixed sugars by Scheffersomyces stipitis free and immobilized cells, and co-cultures with Saccharomyces cerevisiae New Biotechnol 30:591–597 16 Bhadra B, Rao RS, Singh PK, Sarkar PK, Shivaji S (2008) Yeasts and yeast-like fungi associated with tree bark: diversity and identification of yeasts producing extracellular endoxylanases Curr Microbiol 56:489–494 17 Sreenath H, Jeffries T (2000) Production of ethanol from wood hydrolyzate by yeasts Bioresour Technol 72:253–260 18 Rao RS, Bhadra B, Shivaji S (2008) Isolation and characterization of ethanol-producing yeasts from fruits and tree barks Lett Appl Microbiol 47:19–24 19 Long TM, Su YK, Headman J, Higbee A, Willis LB, Jeffries TW (2012) Cofermentation of glucose, xylose, and cellobiose by the beetle-associated yeast Spathaspora passalidarum Appl Environ Microbiol 78:5492–5500 Sharma et al Chemistry Central Journal (2018) 12:8 20 Nogué VS, Karhumaa K (2014) Xylose fermentation as a challenge for commercialization of lignocellulosic fuels and chemicals Biotechnol Lett 37:761–772 21 Lachance MA, Bowles JM, Starmer WT, Barker JS (1999) Kodamaea kakaduensis and Candida tolerans, two new ascomycetous yeast species from Australian Hibiscus flowers Can J Microbiol 45:172–177 22 Daniel HM, Vrancken G, Takrama JF, Camu N, De Vos P, De Vuyst L (2009) Yeast diversity of Ghanaian cocoa bean heap fermentations FEMS Yeast Res 9:774–783 23 Zhu HY, Xu H, Dai XY, Zhang Y, Ying HJ, Ouyang PK (2010) Production of d-arabitol by a newly isolated Kodamaea ohmeri Bioprocess Biosyst Eng 33:565–571 24 Altschul SF, Madden TL, Schaffer AA, Zhang J, Zhang Z, Miller W, Lipman DJ (1997) Gapped BLAST and PSI-BLAST: a new generation of protein database search programs Nucleic Acids Res 25:3389–3402 25 Qi X, Luo Y, Wang X, Zhu J, Lin J, Zhang H, Chen F, Sun W (2015) Enhanced d-arabitol production by Zygosaccharomyces rouxii JM-C46: isolation of strains and process of repeated-batch fermentation J Ind Microbiol Biotechnol 42:807–812 26 McMillan J (1993) Xylose fermentation to ethanol A review National Renewable Energy Lab, Golden 27 Updegraff DM (1969) Semi micro determination of cellulose in biological materials Anal Biochem 32:420–424 28 Mohanram S, Rajan K, Carrier DJ, Nain L, Arora A (2015) Insights into biological delignification of rice straw by Trametes hirsuta and Myrothecium roridum and comparison of saccharification yields with dilute acid pretreatment Biomass Bioenergy 76:54–60 29 Miller GL (1959) Use of dinitrosalicylic acid reagent for determination of reducing sugar Anal Chem 31:426–428 30 Arora A, Priya S, Sharma P, Sharma S, Nain L (2016) Evaluating biological pretreatment as a feasible methodology for ethanol production from paddy straw Biocatal Agric Biotechnol https://doi.org/10.1016/j bcab.2016.08.006 31 Tyagi N, Madan H, Pathak S (2014) Phytochemical screening and estimation of total phenolics and total flavonoid content of Lagenaria siceraria, Praecitrullus fistulosus (50:50) fruit and their mixture IJPRS 3(2):882–890 32 Kimura M (1980) A simple method for estimating evolutionary rate of base substitutions through comparative studies of nucleotide sequences J Mol Evol 16:111–120 Page 11 of 11 33 Freitas LFD, Barriga EJC, Barahona PP, Lachance MA, Rosa CA (2013) Kodamaea transpacifica f.a., sp nov., a yeast species isolated from ephemeral flowers and insects in the Galápagos Islands and Malaysia: further evidence for ancient human transpacific contacts Int J Syst Evol Microbiol 63:4324–4329 34 Rosa CA, Lachance MA, Starmer WT, Barker JSF, Bowles JM, Schlag-Edler B (1999) Kodamaea nitidulidarum, Candida restingae and Kodamaea anthophila, three new related yeast species from ephemeral flowers Int J Syst Bacteriol 49:309–318 35 Sylvester K, Wang Q, James B, Mendez R, Hulfachor A, Hittinger C (2015) Temperature and host preferences drive the diversification of Saccharomyces and other yeasts: a survey and the discovery of eight new yeast species FEMS Yeast Res 15(3):fov002 36 Yokoyama SI, Suzuki T, Kawai K, Horitsu H, Takamizawa K (1995) Purification, characterization and structure analysis of NADPHdependent d-xylose reductase from Candida tropicalis J Ferment Bioeng 79(3):217–223 37 Ikeuchi I, Kiritani R, Azuma M, Ooshima H (2000) Effect of d-glucose on induction of xylose reductase and xylitol dehydrogenase in Candida tropicalis in the presence of NaCl J Basic Microbiol 40(3):167–175 38 Hahn-Hagerdal B, Karhumaa K, Fonseca C, Spencer-Martins I, GorwaGrauslund MF (2007) Towards industrial pentose-fermenting yeast strains Appl Microbiol Biotechnol 74:937–953 39 Parajó J, Domínguez H, Domínguez J (1996) Charcoal adsorption of wood hydrolysates for improving their fermentability: influence of the operational conditions Bioresour Technol 57:179–185 40 van der Pol EC, Bakker RR, Baets P, Eggink G (2014) By-products resulting from lignocellulose pretreatment and their inhibitory effect on fermentations for (bio) chemicals and fuels Appl Microbiol Biotechnol 98:9579–9593 41 Wikandari R, Millati R, Syamsiyah S, Muriana R, Ayuningsih Y (2010) Effect of furfural, hydroxyl methyl furfural and acetic acid on indigeneous microbial isolate for bioethanol production Agric J 5:105–109 42 Banerjee N, Bhatnagar R, Viswanathan L (1981) Inhibition of glycolysis by furfural in Saccharomyces cerevisiae Eur J Appl Microbiol Biotechnol 11:226–228 43 Orij R, Brul S, Smits GJ (2011) Intracellular pH is a tightly controlled signal in yeast Biochimica Biophysica Acta 1810:933–944 ... and strain Table S2 Ethanol production, sugar consumption and fermentation efficiency of K ohmeri strain and strain during xylose fermentation Figure S1 Growth of K ohmeri strain and strain on. .. buffer concentration on the batch xylitol production by Candida guilliermondii Lett Appl Microbiol 42:321–325 13 Jeffries TW (1981) Conversion of xylose to ethanol under aerobic conditions by Candida... ATPase by pumping out protons from the cell, thereby, leading to the production of additional ATPs by increasing ethanol production under anaerobic conditions due to enhanced biomass formation This